1. Киришүү
This manual provides essential information for the safe and efficient operation of your Anern AN-PVI Series Photovoltaic Inverter. Please read this manual thoroughly before installation and use, and keep it for future reference.
Негизги өзгөчөлүктөрү:
- Таза синус толкунунун чыгышы.
- Конфигурациялануучу киргизүү томtage range for various applications via LCD settings.
- Compatibility with mains voltage.
- Кондиционер калыбына келгенде автоматтык түрдө өчүрүп-күйгүзүү.
- Integrated protection against overload, over-temperature, and short circuits.
- Муздак баштоо функциясы.
- Dual MPPT for 6KW models and three MPPT for 10KW models.
- Capable of running 3-phase motors: 6KW model supports 3P motors, 10KW model supports 1.5P+3P motors.
- Designed for full load operation using solar power only.
- IP21 кирүүгө коргоо.
- Maximum conversion efficiency of 97%.
- Important Note: This inverter does not support connection to batteries.
2. Орнотуу жана орнотуу
Proper installation is crucial for the safe and optimal performance of your inverter. Ensure all connections are secure and follow local electrical codes.
2.1 Системалык диаграмма
The following diagram illustrates a typical system setup for the Anern AN-PVI inverter, integrating solar panels, a generator, the utility grid, and various loads, including a water pump system.
2.2 Product Appearance and Connection Points
Familiarize yourself with the inverter's physical layout and connection terminals before proceeding with installation.
- Utility Input: Connects to the main utility grid.
- Photovoltaic Input (PV1, PV2, PV3): Connects to your solar panel arrays. Ensure correct polarity and voltage.
- Utility Output: Connects to your household or facility loads.
- Inverter Switch (ON/OFF): Инвертор үчүн негизги кубат которгучу.
- CT Backflow Prevention Interface: For connecting a Current Transformer (CT) module, if required for grid-tie applications in your region.
- Ground Wire Terminal: Essential for safety grounding.
2.3 Орнотууга чейинки эскертүүлөр
- The inverter is designed for direct power conversion and cannot be connected to batteries.
- For PV-only operation (without mains power), the PV voltage must be greater than 150Vdc for the inverter to start.
- When connecting to a water pump, ensure the inverter's power capacity is 5-7 times greater than the water pump's power. This inverter is suitable only for domestic small water pumps.
- If connecting to the grid, ensure your local regulations do not require specific grid connection certifications that this inverter may not possess. A CT module may be required; please consult your supplier.
3. Иштөө нускамалары
Follow these steps for safe and effective operation of your inverter.
3.1 Startup and Shutdown Sequence
- Ишке киргизүү: Always turn on the inverter first, then activate the connected loads.
- Өчүрүү: Always shut down the connected loads first, then turn off the inverter.
3.2 Output Source Priority Configuration
The inverter allows you to configure the priority of power sources for your loads. This setting can typically be adjusted via the LCD interface.
- Utility First (Default): The inverter will prioritize power from the utility grid to supply the loads. Solar power will only be used to power the loads when utility power is unavailable.
- Күн биринчи: Solar energy is the primary power source for the loads. If solar energy is insufficient to power all connected loads, the utility grid will supply power simultaneously. If both solar energy and utility power are unavailable, or if solar energy is insufficient and utility power is not available, the loads will not receive power.
3.3 ЖК орнотуулары
The inverter features an LCD display for monitoring system status and configuring various parameters, including the input voltagтиричилик техникалары жана жеке компьютерлер үчүн электрондук диапазон.
Refer to the on-screen menu for navigation and adjustment of settings.
4. Техникалык тейлөө
Regular maintenance ensures the longevity and reliable performance of your inverter.
- Тазалоо: Keep the inverter's exterior clean and free from dust and debris. Use a dry, soft cloth for cleaning. Do not use liquid cleaners.
- Вентиляция: Ашыкча ысып кетүүнүн алдын алуу үчүн желдетүү тешиктери ачык жана тоскоолдуксуз экенине ынаныңыз.
- Байланыштары: Periodically check all electrical connections (PV input, AC input, AC output, ground) for tightness and signs of corrosion.
- Экологиялык шарттар: The inverter has an IP21 ingress protection rating, meaning it is protected against solid objects over 12.5mm and vertically falling drops of water. Avoid exposing the inverter to direct water spray or harsh weather conditions.
5. Кыйынчылыктарды
Бул бөлүм жалпы маселелер боюнча жетекчиликти камсыз кылат. Татаал маселелер боюнча квалификациялуу тейлөө кызматкерлерине кайрылыңыз.
| Көйгөй | Мүмкүн себеп | Чечим |
|---|---|---|
| Inverter does not start with PV power only. | PV томtage is below the minimum required (150Vdc). | Ensure PV voltage is above 150Vdc. Check solar panel connections and sunlight conditions. |
| Инвертор күтүлбөгөн жерден өчүп калат. | Overload, over-temperature, or short circuit detected. | Reduce connected load, check for obstructions to ventilation, inspect wiring for short circuits. Allow inverter to cool down before restarting. |
| Loads not receiving power. | Incorrect startup/shutdown sequence, insufficient solar/utility power, or inverter fault. | Follow correct startup sequence (inverter ON, then loads ON). Check power source availability (solar, utility). Verify output source priority setting. |
| Attempting to connect batteries. | Misunderstanding of inverter capabilities. | This inverter model does not support battery connections. Do not attempt to connect batteries. |
6. Техникалык шарттар
Detailed technical specifications for the Anern AN-PVI-6000W and AN-PVI-10000W models.
| Параметр | AN-PVI-6000W | AN-PVI-10000W |
|---|---|---|
| Генерал | ||
| Модел | AN-PVI-6000W | AN-PVI-10000W |
| Номиналдуу кубаттуулук | 6КВА/6КВт | 10КВА/10КВт |
| Фаза | 1 фазалуу кириш/1 фазалык чыгуу | |
| PV Input (DC) - Grid-Tie Operation | ||
| Максималдуу PV киргизүү күчү | 4500 Вт * 2 | 4500 Вт * 3 |
| Максималдуу DC Voltage | 500Vdc | |
| Start-up Voltage / Баштапкы тамактандыруу томtage | 90Vdc / 120Vdc | |
| MPPT Voltage Диапазон | 60-450Vdc | |
| MPP Trackers саны / Максималдуу киргизүү агымы | 2/18A | 3/18A |
| Тордун чыгышы (AC) | ||
| Номиналдуу Чыгуу Voltage | 220/230 / 240VAC | |
| Output Voltage Диапазон | 184-264.5VAC or 195.5-253VAC or 184-264.4VAC (Selectable) | |
| Номиналдык чыгуу агымы | 26A | 43A |
| Power Factor | >0.99 | |
| Натыйжалуулук | ||
| Конверсиянын максималдуу эффективдүүлүгү (DC/AC) | 97% | |
| AC Input - Off-Grid Operation | ||
| AC Start-up Voltage / Auto Restart Voltage | 120-140VAC / 180VAC | |
| Кабыл алынуучу Input Voltage Диапазон | 90-280VAC же 170-280VAC | |
| Жыштык диапазону | 50Гц/60Гц (Авто сезүү) | |
| Максималдуу AC киргизүү агымы | 40A | 50A |
| Физикалык | ||
| Өлчөмү (D x W x Y) | 360x278x106 мм | 360x310x107 мм |
| Таза Салмак | 4.9 кг | 6.5 кг |
| Интерфейс | ||
| Параллель функция | Жок | |
| Байланыш порту | RS232 (WIFI), CAN (Parallel) | |
| Курчап турган чөйрө | ||
| Нымдуулук | 5%дан 95%га чейин Салыштырмалуу нымдуулук (конденсацияланбаган) | |
| IP даражасы | IP21 | |
| Иштөө температурасы | -10 градустан 50 градуска чейин | |
| Сактоо температурасы | -15 градустан 60 градуска чейин | |
7. Кепилдик жана колдоо
For warranty information, terms, and conditions, please refer to the documentation provided at the time of purchase or contact your seller directly. For technical support or service inquiries, please contact Anern customer service or your authorized dealer.
8. Колдонуучунун кеңештери
- Verify Specifications: Сатып алуудан мурунasing or installing, always confirm the exact model specifications (e.g., 6KW vs. 10KW) and physical dimensions to ensure it meets your requirements.
- No Battery Support: Remember that this inverter series is designed for direct power conversion and does not support battery storage. Do not attempt to integrate batteries into the system.
- Grid-Tie and Off-Grid Functionality: The AN-PVI series supports both grid-tie and off-grid operations. Ensure your setup and configuration match your intended use and local regulations.
- Water Pump Sizing: If using with a water pump, ensure the inverter's power rating is significantly higher (5-7 times) than the pump's power for optimal performance and to prevent overload. This inverter is primarily for domestic small water pumps.
