Introduction
This manual provides detailed instructions for the safe installation, operation, and maintenance of the White Rodgers 36E38-301 Gas Valve. This valve is specifically designed for natural gas applications only and operates on a 24 VAC power supply. It features a redundant (pilot) valve design with specified outlet pressures for optimal performance in compatible heating systems.
Маанилүү коопсуздук нускамалары
WARNING: Improper installation, adjustment, alteration, service, or maintenance can cause property damage, personal injury, or loss of life. Read these instructions thoroughly before installing or servicing this equipment.
- Орнотуу жана тейлөө квалификациялуу орнотуучу, тейлөө агенттиги же газ берүүчү тарабынан аткарылышы керек.
- Disconnect the electrical power supply before making any wiring connections to prevent electrical shock or equipment damage.
- Ensure all gas connections are tight and leak-free before operating the valve. Use a non-corrosive leak detection solution.
- Do not use this valve with any gas type other than natural gas.
- Always follow local codes and regulations governing gas appliance installation and safety.
Продукт өзгөчөлүктөрү
- Модел: 36E38-301
- Газ түрү: Жаратылыш газы гана
- Тtage: 24 VAC
- Клапандын түрү: Redundant (Pilot) Valve
- Кирүүчү туташуу: 1/2 дюйм
- Розетка туташуу: 3/4 дюйм
- Step Outlet Pressure: 1.2 дюймдук WC
- Full Outlet Pressure: 3.5 дюймдук WC
- Тышкы жасалгалоо: Дат баспаган болот
- Порттардын саны: 2
- Шайкештик: ANSI Z21.24
Орнотуу жана орнотуу
Note: Installation should only be performed by a qualified technician.
- Орнотууга чейинки текшерүү:
- Verify that the gas valve model (36E38-301) matches the system requirements for natural gas and 24 VAC.
- Ensure the gas supply is turned off at the main valve.
- Disconnect electrical power to the appliance.
- Монтаждоо:
- Mount the valve securely in the correct orientation as specified by the appliance manufacturer.
- Ensure adequate clearance for wiring and gas piping.
- Газ түтүктөрүнүн туташуулары:
- Apply pipe sealant suitable for natural gas to all male pipe threads. Do not apply sealant to the first two threads.
- Connect the gas supply line to the inlet port (1/2").
- Connect the appliance manifold to the outlet port (3/4").
- Tighten all connections firmly but do not overtighten.
- Электр зымдары:
- Connect the 24 VAC power supply wires to the appropriate terminals on the valve as per the appliance wiring diagram.
- Бардык байланыштар коопсуз жана изоляцияланганын текшериңиз.
- Ачуу сыноо:
- Негизги газ менен камсыз кылууну күйгүзүңүз.
- Apply a non-corrosive leak detection solution to all gas connections.
- Bubbles indicate a leak. Tighten connections or reapply sealant as necessary.
- Газдын агып кетишин текшерүү үчүн эч качан ачык отту колдонбоңуз.
- Алгачкы ишке киргизүү:
- Restore electrical power to the appliance.
- Алгачкы ишке киргизүү жана пилоттук жарыктандыруу процедуралары үчүн шайманды өндүрүүчүнүн көрсөтмөлөрүн аткарыңыз.
No relevant official product videos for installation from a 'Seller' were found in the provided data.
Иштөө нускамалары
The White Rodgers 36E38-301 Gas Valve operates in conjunction with your appliance's control system. It is designed to regulate the flow of natural gas to the burner based on demand.
- Кадимки операция: When the appliance's control system calls for heat, it sends a 24 VAC signal to the gas valve.
- Pilot Ignition: The redundant pilot valve opens first, allowing gas to flow to the pilot burner for ignition.
- Main Burner Ignition: Once the pilot is established and sensed by the control system, the main valve opens, allowing gas to flow to the main burner for heating.
- Өчүрүү: When the heat demand is satisfied, the 24 VAC signal is removed, and the gas valve closes, shutting off the gas supply to both the pilot and main burners.
Important: Do not attempt to manually operate the valve unless specifically instructed by a qualified technician during troubleshooting or service procedures.
No relevant official product videos for operation from a 'Seller' were found in the provided data.
Техникалык тейлөө боюнча көрсөтмөлөр
The White Rodgers 36E38-301 Gas Valve is designed for reliable operation with minimal maintenance. However, periodic checks are recommended to ensure continued safe and efficient performance.
- Жылдык текшерүү: Have a qualified technician inspect the gas valve and all gas connections annually for signs of wear, corrosion, or leaks.
- Тазалоо: Keep the area around the gas valve clean and free from dust, debris, and obstructions. Do not use harsh chemicals or abrasive cleaners on the valve body.
- агып текшерүүлөр: Periodically perform a leak check on all gas connections using a non-corrosive leak detection solution.
- Pilot Flame Inspection: If applicable to your appliance, ensure the pilot flame is stable, blue, and properly impinging on the thermocouple/thermopile. Refer to your appliance manual for specific pilot adjustment procedures.
Caution: Do not attempt to disassemble or repair the gas valve. If the valve is found to be faulty, it must be replaced by a qualified technician.
No relevant official product videos for maintenance from a 'Seller' were found in the provided data.
Жалпы көйгөйлөрдү чечүү
Бул бөлүм жалпы маселелер боюнча жетекчиликти камсыз кылат. Татаал көйгөйлөр үчүн же ишенбесеңиз, ар дайым квалификациялуу тейлөө техникине кайрылыңыз.
| Көйгөй | Мүмкүн себеп | Чечим |
|---|---|---|
| Отургычка газ агымы жок | Gas supply off; Electrical power off; Faulty thermostat/control; Faulty gas valve | Check main gas supply; Check electrical breaker/fuse; Verify thermostat setting; Contact technician for valve inspection or replacement. |
| Пилоттун жарыгы күйүп турбайт | Dirty pilot orifice; Faulty thermocouple/thermopile; Low gas pressure | Clean pilot orifice; Replace thermocouple/thermopile; Contact gas supplier or technician for pressure check. |
| Газдын жыты аныкталды | Газ агып кетүү | Immediately turn off gas supply and ventilate area. Do not operate electrical switches or create sparks. Contact your gas company and a qualified technician immediately. |
Продукт спецификациялары
- Модель номери: 36E38-301
- Бренд: Уайт-Роджерс
- Өндүрүүчү: Ак Роджерс
- Газ түрү: Жаратылыш газы гана
- Тtage: 24 VAC
- Клапандын түрү: Redundant (Pilot)
- Кирүүчү туташуу: 1/2 дюйм
- Розетка туташуу: 3/4 дюйм
- Step Outlet Pressure: 1.2 дюймдук WC
- Full Outlet Pressure: 3.5 дюймдук WC
- Тышкы жасалгалоо: Дат баспаган болот
- Порттардын саны: 2
- Шайкештик: ANSI Z21.24
- Биринчи жеткиликтүү датасы: 27-апрель, 2007-жыл
Эскертүү: Техникалык мүнөздөмөлөр эскертүүсүз өзгөртүлүшү мүмкүн.
Кепилдик маалымат жана техникалык колдоо
Specific warranty details for the White Rodgers 36E38-301 Gas Valve are typically provided with the product packaging or can be obtained directly from the manufacturer or an authorized distributor.
For technical support, service, or warranty claims, please contact White-Rodgers customer service or an authorized service center.
Өндүрүүчүнүн Байланыш маалыматы:
- Бренд: Уайт-Роджерс
- Webсайт: Emerson - White-Rodgers
Please refer to the product packaging or the manufacturer's webэң акыркы байланыш маалыматтары жана колдоо ресурстары үчүн сайт.
No relevant official product videos for warranty or support from a 'Seller' were found in the provided data.
